Previous Next
ITEM DETAILS
Meter Reading
4,700 Hours
Serial #
56,000 GVWR, Cummins NTC 350 eng, 13spd trans, air brakes, 16' bed length, 8' width

Inspection Report



Please note that as the buyer, you are responsible for reviewing the entire inspection report when evaluating an item.
Summary Protected by IronClad Assurance Protected by IronClad Assurance®
This dump truck appears to be in good overall condition. The engine and powertrain perform well. The electrical could use attention. The chassis and dump bed are in good condition. The sheet metal and paint are good.


General Appearance
Description Rating Details  
sheet metal (fiberglass) condition There is minor rust in places where the paint is missing.
paint The paint is faded and chipped on the bed. Click here to open photos and videos of this item.  
(1)


Operator Station
Description Rating Details  
axle ratings, front/rear 56,000 GVWR
steps/ladders
hand rails
mirrors
glass The windshield is cracked with rock chips.
seats/armrests The seat is worn. Click here to open photos and videos of this item.  
seat belts Click here to open photos and videos of this item.  
horn The air horn is good but the electric horn is inoperable.
powertrain controls Click here to open photos and videos of this item.  
steering controls Click here to open photos and videos of this item.  
hydraulic controls
oil pressure 40psi at idle on the gauge - There was a also a warning light that went out when the engine started.
exterior lights Undetermined
warning lights/alarms
travel alarms INOPERABLE - The back up alarm is inoperable.
gauges INOPERABLE
odometer operational No - The odometer and tach are inoperable.
heater INOPERABLE
limited function check The components that were checked performed properly with wear and damage as noted. Click here to open photos and videos of this item.  
(5)


Engine
Description Rating Details  
hour meter/odometer 4700 on hour meter/283,099 on inoperable odometer
make & model Cummins NTC 350 Click here to open photos and videos of this item.  
serial # 11374999
blowby (checked at idle) Minimal
starter
battery Had to be jump started.
turbocharger Click here to open photos and videos of this item.  
injector pump
radiator
air compressor There are signs of minor oil seepage on the top of the compressor.
exhaust system Click here to open photos and videos of this item.  
cylinder head gasket leaks None Seen
valve cover gasket leaks None Seen
oil pan & gasket leaks None Seen
fuel line & injector leaks None Seen
water pump
limited function check The power steering hose has a small leak. The engine ran well and sounded good after being jumped.
(3)


Powertrain
Description Rating Details  
transmission type 13 speed manual
clutch
power take off
differential There is some oil accumulation on the rear differential. Click here to open photos and videos of this item.  
limited function check The powertrain functioned well when checked without a load. Click here to open photos and videos of this item.  
(2)


Chassis
IronPlanet pin connection pivot point wear inspections are limited to sound, sight and feel observations. Dial indicator testing is not performed.
Description Rating Details  
springs & hangers
walking beams
external electrical/air connections
steering linkage Minimal wear
steering wheel play Minor
limited function check The main chassis components functioned properly with minor wear in the pivot points.
brake type Air
master cylinder N/A - Foot control valve Click here to open photos and videos of this item.  
brake lines/hoses
park brake
limited function check The brake system functioned well, stopping and holding the machine.
tire size 10.00R20 Click here to open photos and videos of this item.  
tire condition L/F 10/32", L/M/O 8/32", L/M/I 3/32", L/R/O 3/32", L/R/I 12/32", R/F 7/32", R/M/I 10/32", R/M/O 10/32", R/R/I 6/32", R/R/O 3/32" The R/R/O is flat. Click here to open photos and videos of this item.  
wheel condition Click here to open photos and videos of this item.  
wheel studs, nuts, or bolts Click here to open photos and videos of this item.  
(5)


Hydraulics
Description Rating Details  
pumps
valves Click here to open photos and videos of this item.  
hoses Click here to open photos and videos of this item.  
cylinders There is minor seepage on the bottom stage of the dump cylinder.
cylinder pins & bushings Minor wear
limited function check The system performed well when checked without a load. See the oil sample analysis for the hydraulic system.
(2)


Specialty Equipment
Description Rating Details  
dump bed condition 16' long 8' wide. The bed was holding water. Click here to open photos and videos of this item.  
cylinder hoist Slight seepage at bottom of cylinder. Click here to open photos and videos of this item.  
rear pivot points Click here to open photos and videos of this item.  
crossmembers Click here to open photos and videos of this item.  
(4)


Additional Photos
(5)
 

Oil Sample Analysis
  engine hydraulic
date of analysis Feb 19, 2003 Feb 19, 2003
analysis by Spectro Spectro
Tin 3 PPM 2 PPM
Chromium 0.5 PPM 0.2 PPM
Copper 3 PPM 240 PPM
Nickel 0.4 PPM 0.2 PPM
Lead 3 PPM 1 PPM
Magnesium 22 PPM 26 PPM
Water 0 % 0 %
Silver 0 PPM 0 PPM
Iron 23 PPM 13 PPM
Silicon 9 PPM 15 PPM
Sodium 5 PPM 12 PPM
Aluminum 3 PPM 1 PPM
Glycol N N
Disputes:
This item is offered with IronClad Assurance® protection. With IronClad Assurance®, if a buyer discovers that the item is not substantially in the condition as represented in this inspection report, the buyer may submit a written dispute claim to IronPlanet. Following submission of a written dispute claim, IronPlanet will investigate the claim, re-inspecting the equipment item as necessary, and determine a fair and mutually beneficial resolution. Please note that IronPlanet inspections are performed solely for the purpose of reporting the visible condition of the equipment's major systems and attachments on the day of the inspection and do not include load testing or digging/lifting. These inspections are not designed nor intended to detect latent defects, or conditions that could only be found in connection with the physical dismantling of the equipment or the use of diagnostic tools or techniques. This inspection report includes ratings, comments, and photos of the various components of the item. Knowledgeable buyers are expected to carefully review all of the available information in the inspection report, including all photographs, in order to make the best bidding and buying decision possible.